Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- A/C - Unpleasant Odors Coming From Vents
- A/C - Unpleasant Musty Odor
- Engine - Idle Speed Hunts When Cold
- Fuel System - Poor Engine Performance
- A/C Evaporator - Water Leaking From Vents
- Coolant Pump - Leakage, Warning Lamp On, Residue
- Alternator - V Belt Slips Under Load
- ECM - Inoperative Due to Improper Battery Charging
- Engine - Poor Performance, Hesitation, or Surge
- Engine - Lack of Power, Stalls, Bucking, and Jerking
- Instrument Warning Lights - Inoperative at Times
- Engine - Ignition Miss or Does Not Start
- Speedometer - Noisy
- Wiper Blade - Smearing Windshield
- Wiper Blade - Chatter and Skipping
- Wiper Blades - Jerk or Skip Across Windshield
- CD Changer - Skipping Over Rough Roads
- Engine - Misfire
- Engine - Rough Idle, Stalls
- MIL ON - Poor Idle/Stalls, Loss of Power, Exhaust Smoke
- Tires/Suspension - Vehicle Pulls to one side
- Wheels/Tires - Vibrations
- Interior Trim - Dirty/Soiled
- Radio - Causes Excessive Battery Drain
- Final Drive Housing Cover - Leakage
- Superceded Bulletins
- 408902 - 10/31/89
- WARR9004V - 03/12/90
- 879102 - 03/31/91
- WARRV9224 - 11/02/92
- WARRV9313 - 06/15/93
- V9320 - 09/01/93
- 7093-04 - 11/15/93
- 8798-01 - 02/05/98
- 179002 - 10/31/90
- 008803 - 10/10/88
- Vehicle - Component Nomenclature Revisions
- Speedometer - Replacement, Government Regulations
- Speedometer - Noise in Magnet Shaft Bearing
- Body/Interior - Squeak and Rattle Kit Availability
- Interior Leather Upholstery - Cleaning Tips
- Interior - Fabrics, Vinyls and Plastics, Cleaning Tips
- Audio System - Antitheft Security Code Retrieval
- Restraint System - 'LATCH' System Installation/Retrofit
- Child Restraint - Anchor Installation/Retrofitting
- A/C - Musty Odors
- A/C - Unpleasant Musty Odors
- Electrical Contact Enhancer - Improves Contact Surface
- Electrical -Diagnosis for Excessive Static Current Draw
- Brakes - Abnormal Vibration When Braking
- Fuel Tank - Fuel Neutralization After Removal
- Engine - Intermittent Misfire, Stalls, Lack of Power
- A/T - Erratic, Harsh, or Delayed Upshifts
- Oxygen Sensor - Possible Damage Using Silicone
- Body - Underbody Heat Shield Information
- Engine - Replacement Precautions
- Alloy Wheels - Build Up of Road Dirt or Brake Dust
- All Technical Service Bulletins
- A/C - Unpleasant Odors Coming From Vents
- Electrical - Diagnosis for Excessive Static Current Draw
- WARR8602V - 04/15/86
- Warranty - Defect in Materials or Workmanship Policy
- Platform Wiring Harness - Repairing
- Emissions - IM 240 Testing on All Wheel Drive Vehicles
- Vehicle - Ordering VIN Plates/Safety And Emission Labels
- Electrical Contact Enhancer - Enhances Conductivity
- Electrical - Aftermarket Equipment Installation
- Warranty - Plastic Bags for Electronic Parts Tag
- Fluids and Lubricants - Warranty Reimbursements
- Tools - Preventing Damage to VAG 1551 Diagnostic Tester
- Warranty - Updated Policies and Procedures Manual
- Warranty - Replacement Price Estimate Guidelines
- Warranty - Loaner Car Charges, Paint/Corrosion Repairs
- Tools - Repairing Manual Transmissions
- Tools - Special Tool Minimum Requirements
- Overview
- Volkswagen Dealer Minimum Requirement Special Tools
- Volkswagen Dealer Minimum Requirement Test Equipment
- Volkswagen Dealer Minimum Requirement Metric Measuring
- Volkswagen Dealer Minimum Requirement Workshop Equipment
- Volkswagen Dealer Minimum Requirement - Service Information
- Volkswagen/Audi Dealer Minimum Requirement Special Tools
- Volkswagen/Audi Dealer Minimum Requirement Test Equipment
- Volkswagen/Audi Dealer Minimum Requirement Metric Measuring
- Volkswagen/Audi Dealer Minimum Requirement Workshop Equipment
- Volkswagen/Audi Dealer Minimum Requirement Service Information
- Tools - Digital Multimeter (Fluke 83) Introduction
- Engine Control Harness Connector Terminals - Replacing
- Repair Group Numbers - Renamed in Service Manual
- Vehicle - Lubricant Capacities and Type
- A/C - Wiring Diagram Manual Revision
- Warranty - Camper Refrigerator Service Center List
- A/C System - Retrofitting R-12 to R-134a
- A/C - Unpleasant Musty Odor
- A/C Refrigerant - Compliance With Enviromental Laws
- Tools - Engine/Transmission Oil Temperature Tester
- Engine - Warranty Repair Claims No Longer Covered
- Engine - Oil Consumption
- Engine - Idle Speed Hunts When Cold
- Fuel System - Poor Engine Performance
- Tools - Adapter for Brake Pressure Regulator Adjustment
- Recall 93V175000: Air Duct Cracking
- A/C Compressor Clutch - Removal and Installation
- A/C Evaporator - Water Leaking From Vents
- Engine - Attach Pressure Plate or Flywheel to Crankshaft
- Coolant Pump - Leakage, Warning Lamp On, Residue
- Alternator - V Belt Slips Under Load
- Warranty - Replacement Mufflers Warranty
- Tires - Goodyear Tire And Rubber Toll Free Line
- Tires - Aerosol Inflator/Sealer Flammability Hazard
- CV Joint - Revised Diagnosis, Inspection and Replacement
- M/T - When Replacing, Match Flanges to Driveshafts
- Warranty - Component Repair vs. Replacement Policy
- ECM - Inoperative Due to Improper Battery Charging
- Oxygen Sensor - Failure Due to Silicone
- Engine - Poor Performance, Hesitation, or Surge
- Engine - Lack of Power, Stalls, Bucking, and Jerking
- Wheel Brake Cylinder, Rear - Replacement Criteria
- Alternator Shaft - Design Changed
- Tools - Removing and Installing Generator V-Belt Pulley
- Instrument Warning Lights - Inoperative at Times
- Knock Sensor - Avoiding Unnecessary Replacement
- Engine - Ignition Miss or Does Not Start
- Recall 92V058000: Leakage at Fuel Rail
- Accelerator Cable - Modified
- Exhaust - Sulfur Odor Noticed At the Pipe
- Warranty - Locked-Up Radio Repair Program
- Warranty - Radio Handling Allowance Increased
- Warranty - Unlocking Non-Fixed Code Radios Locked-Up
- Radio - Diagnosis Instructions
- Vanity Mirror Bulb - Replacement
- Speedometer - Replacement Procedure, Regulations
- Speedometer - Noisy
- Speedometer - Replacement Guidelines
- Tools - Headlights, Aiming, Hella Beamsetter Series IV
- A/C Compressor Shaft Seal - Replacement
- Cylinder Head - Reseal Procedure
- Engine Compartment - Protective Coating
- VAG 1551 Scan Tool Printout - Attach to R/O for Warranty
- Wiper Blade - Smearing Windshield
- Tools - Windshield Wiper Alignment
- Wiper Blade - Chatter and Skipping
- Wiper Blades - Jerk or Skip Across Windshield
- Engine - Approved Oil And Additives
- Coolant - Revision
- Tools - Brake Line Kit
- Tools - Universal Transmission Support 3282
- Tools - New High Lift Transmission Jack
- Warranty - Contact Tech Help Line During A/T Repair
- Warranty - Repairs to Syncro Transmissions
- A/T - Synthetic Oil for Final Drive
- Warranty - Transmission Manufacture Date, Code Letters
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - ATF Leaking From Differential Pinion Seal Vent
- A/T - 010/087/089/090 Bind In Low and Reverse
- A/T - ATF Entering The Differential
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- Flywheel Mounting Bolt - Torque
- CD Changer - Skipping Over Rough Roads
- Engine - Misfire
- Engine - Rough Idle, Stalls
- MIL ON - Poor Idle/Stalls, Loss of Power, Exhaust Smoke
- Fuel - Use of Gasolines Containing Detergent Recommended
- Alignment - Conversion Chart for Specifications
- Tires/Suspension - Vehicle Pulls to one side
- Wheels/Tires - Vibrations
- Interior Trim - Dirty/Soiled
- Radio - Causes Excessive Battery Drain
- Audio System - Radio Security Code Retrieval
- Paint Finishes - Restoration
- Tools - Refrigerant Recovery and Recycling System
- A/C Evaporator - Repair
- Refrigerator Unit Air Supply - Modification
- Final Drive Housing Cover - Leakage
- Engine - Component Inspection During Engine Replacement
- Exhaust System - Heat Shield Replacement Guidelines