Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- A/C - Center Dash Air Vent Repair
- A/C - Evaporator Odor Treatment
- Fuel Pump/Headlight Relay Terminals - Overheating
- Engines - Poor Fuel Performance
- Brake Disc And Pad - General Characteristics
- Exhaust - Booming Noise
- Sunroof - Rattle or Creak
- Sunroof - Leak/Drainage Improved
- Brake Caliper - Rattling Sound
- Front Brakes - Squeal and Rattle
- Front Brake Caliper - Revised
- Radio - Noise Interference
- Radio - Whinning/Crackling Interference Noise
- Radio - Interference On AM Band
- Speedometer Reset Button - Broken
- Windshield Wipers - Noise
- Body - Whistle/Wiper Well Cover Panel Sealing strip
- Windshield Washer Jets - New Filter
- Windshield Wiper - Noise
- Power Antenna - Malfunction
- Clutch - Cable Vibrations and Potential Noise
- Fuse Holder - Deformed
- Engine - Intermittent No Cranking
- Engine - Hard Cold Starting and Performance
- Mirror - Popping Noise in Audio System
- Luggage Compartment Blind - Loss of Tension
- Drive Shaft - Take-Off Vibration at Low Speed
- M/T - Improved Reverse Shift Quality
- Seat Belt - Extensions
- A/C - Climate Control System Cleaning
- A/T - Coolant Contamination Information
- Manual Updates
- Seals, Gaskets
- Tools, Equipment
- Superceded Bulletins
- SB39-004 - 04/16/08
- SB77-006 - 01/13/11
- TJ19245 - 03/22/10
- TJ16773 - 01/16/09
- TNN43-48 - 04/18/07
- 517 - 05/01/87
- 8712 - 03/01/88
- 881 - 07/01/88
- 37702 - 12/01/89
- 37701 - 01/01/90
- 87713 - 04/01/90
- 87713 - 05/01/90
- 36109 - 05/01/90
- 39113 - 04/01/91
- 88-1A - 01/01/99
- 23132 - 05/01/86
- 23129 - 02/01/88
- Power Antenna - Cleaning
- Seat Belt Extender - Front Seat Only
- A/C - Cleaning for System Odors
- Defroster - Driver's Side Outlet Spacer
- Heater Motor - Replacement
- A/C - Replacement of Blower Motor/New Kit Available
- A/T - Cooler/Line Flushing Guidelines
- A/T - Cooler/Line Flushing When Replacing A/T
- Engine Oils - Updated Recommendations
- A/T - Engine Coolant Contamination Detection
- Transmission/Drivetrain - Lubricants And Fluids
- Engine - Required Engine Oils And Maintenance Intervals
- All Technical Service Bulletins
- Memory Systems - Restoring Customer Preferred Settings
- Audio System - CD's Stuck In Audio Units
- Tires/Wheels - Tire Rotation Recommendations
- Wheels - Wheel Cross Reference
- Electrical - Battery Current Consumption And RDAR
- Wheels - Winter Wheel Applications (USA, Canada)
- Electrical - Lead Acid Battery Handling Precautions
- Vehicle - Platform Identification
- Vehicle - Type and Platform Identification
- A/C - Supplement to Service Bulletin 8-87-217
- Tools - New Address For Mono Tester Repairs
- Safety Instructions - Fluoroelastomer Seals
- Vehicle - Chassis Types
- Connector/Wiring - Noise Explainations
- Tools - Volvo Multifunction Tester Updates
- Tools - Volvo Multifunction Tester
- Tools - Bulletin Indexes
- Tools - Replacement Parts or Repairs Made By Motometer
- Tools - Digital Multimeter Now Available
- Recall 84V018000: Fluid Leak From Brake Warning Switch
- Tools - Measuring Brake Disc and Hub Runout
- Tools - R12 Recycling Equipment
- Tools - Charging Station/R-12 Recycling Units Available
- Tools - Light Duty R12 Recovery/Recycling Unit Available
- A/C - Improving Floor Heat Distribution
- A/C - Center Dash Air Vent Repair
- A/C - Evaporator Odor Treatment
- A/C - Conversion, R12 to R134a
- A/C - Condensation On Air Duct Over Glove Box
- Defroster - Outlet Spacer to Direct Air Flow
- A/C - Functional Check
- CU And AC Dash Controls - New Indicating Panel
- A/C - Improved Recirculation Function
- Steering Shaft Bearing Housing - Pending Revision
- Safety Precaution - Fluoroelastomer (Viton) Seals
- Cooling System - Bleeding
- Fuel Pump/Headlight Relay Terminals - Overheating
- Engines - Poor Fuel Performance
- Fuel Pump Hose - Revised, Resistant to Impurities
- Fuel Pump - Noisy
- Prepump Wiring Harness - Replacing With Gasoline Engine
- Prepump Wiring Harness - Replacing
- Brake Disc And Pad - General Characteristics
- Front, Rear Brake Pad - Parts List
- Brakes - Update Service Manual on Paste Application
- Tools - New and Modified
- A/C - York Air Conditioning Compressor Repair
- A/C - Replacement of Blower Motor
- Heater - New Design Fan Housing
- Tools - Special Tool (5407) Must Be Checked
- Cooling System - Installing New Type Water Hose
- Coolant Pump O-Ring - Replacing
- Tools - Diesel Rear Crank Shaft Seal Installer
- Rear Crankshaft Seal - Revised Part And Installation
- Exhaust System - Revised Mounting
- Exhaust - Booming Noise
- A/C - Condenser/Pressure Pipe Connections Changed
- Door - Extended Regulator Channel For Front Side Glass
- Body - Front Window Smoother Winding Action
- Power Seat - Height Adjuster
- Interior - Front Head Restraint Cushion
- Interior - Noise From Seats and Panels
- Interior - New Seat Runners for Manual Seats
- Interior - New Type Lock Bar for Front Seat Adjustment
- Interior - Front Seat Height
- Third Seat - Installation Instructions Modified
- Seats - Slide Rail Replacement
- Seats - Replacement of Catch Pins, Springs and Runners
- Sunroof Rear Sliding Bushing - Correct Install Position
- Sunroof - Rattle or Creak
- Sunroof - Repairing And Resealing
- Sun Roof - Repairs and Adjustments
- Sunroof - Leak/Drainage Improved
- Sunroof - Motor Switch Binds
- Sunroof - Repairing and Resealing
- Tools - Installing Clutch and Pressure Plate
- Low Lift Pressure Plate - Installation
- ATF Filter - Cleaning Deleted
- Oil Cooler Kit - Part Number Update
- Fuel Injectors - Require Regular Maintenance
- Wheel Hub - New Front Unit
- Brake Caliper - Rattling Sound
- Rear Brake Calipers - Revised
- Front Brakes - Squeal and Rattle
- Brake Rotors, Calipers - Revised
- Front Brake Caliper - Revised
- Battery, 500 Amp - Installation Instructions
- Battery Ground Cable - New Routing
- Fuel Tank - Tightening Tips
- Tank Sending Unit - Replacement For Tanks W/Metal Flange
- Emissions - Venting Turbo Exhaust from Shop
- Turbo Wastegate - Sealing Requirements
- Door Switch - Revised
- Radio - Noise Interference
- Radio - Whinning/Crackling Interference Noise
- Warranty - Alternative Radio Claim Procedures
- Radio - Interference On AM Band
- Monotester - Timing Adapter
- Fuel And Ignition Systems - Fault Tracing
- Fuel Gauge Circuit - Operation
- Speedometer Connector - Sealing After Repairs
- Speedometer Reset Button - Broken
- Windshield Wipers - Noise
- Cylinder Head Gasket - Revised
- Parking Brake Cable Bracket - Replacement
- Tools - Replacing Control Arm Bushing
- Body - Sealing
- Body - New Adhesive
- Body - New Repair Equipment and Chemicals
- Body Fittings - Service Manual Change
- Body - Whistle/Wiper Well Cover Panel Sealing strip
- Body - Changes in Service Manual Section 8
- Body - Using Surge Protectors While Arc Welding
- Welding Precautions for Electrical Components
- Antitheft Alarm - Fault Tracing (Watchdog 2)
- Monotester - Repair and Handling Procedure
- Rear Speakers - Sound Quality Problems
- Windshield Washer Jets - New Filter
- Body - Modification of New Door to Fit Earlier Models
- Interior - Retaining Clip Front Door Trim Panel
- Body - Aluminum Hoods
- Seat Belts - Front Belts Dual Retractor System
- Windshield - New Trim Moulding
- Windshield Moulding - Noise
- Window - Replacement, Manual Supplement
- Windshield - Removing/ Installing
- Wiper Arm Nut - Plastic Cover
- Windshield Wiper - Noise
- Outside Mirror Glass - Replacement
- Body - Rear Quarter Window Lower Moulding Clips
- Oil - Abnormal Consumption
- Engine Oils - Suggested Usage
- Engine Oil - Viscosity Recommendation
- Engine - Oil Change Quantity Correction
- Cooling System - Recycled Antifreeze
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - A40 Series O/D Won't Cancel Fourth Gear
- A/T - A40 Series Needle Bearing Identification
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- A/T - Slips or No Reverse, Slips In 2-3
- First Gear/Needle Bearings - Revised
- M/T - Replacing Short Dog Keys With Long Dog Keys
- Power Antenna - Malfunction
- Automatic Transmission - Recommended Oil
- A/T Fluid - Correct Applications
- A/T, M/T, AWD - Approved Lubricants
- Engine - Intermittent Preheating System Problems
- Tools - Dial Indicator Measures Diesel Injection Timing
- Diesel Injection Pump - Setting
- Clutch - Cable Vibrations and Potential Noise
- Fuse Holder - Deformed
- I/P, Knee Bolster Member - Modification
- Odometer - Information Sticker Used After Replacing
- A/C - ACC Programmers
- Engine Oil - Recommended
- Engine - Intermittent No Cranking
- Electrical - Ground Test By Voltage Drop
- Electrical/Electronic Systems - Fault Tracing
- Sealed Crimping Sleeve - New
- Fuel - Diagnosis of Contamination
- Engine - Hard Cold Starting and Performance
- Cruise Control - Correction to Fault Tracing
- Alignment - New Wheel Angle Tolerances
- Alignment - Camber And Caster Adjustment
- Positive/Negative Clutch - Adjustment
- M/T - New Driven Plates and Release Bearing
- Rear Windows - Replacement
- Mirror - Popping Noise in Audio System
- Seat Belt - Extender Available
- Seat Belt - Extender Availability For Front Seats
- Luggage Compartment Blind - Loss of Tension
- Glass - Replacement
- Audio - Diagnostic Check List
- Paint - New Supplier
- Paint - Approved Products
- Reversing Light Lens - Replacement
- Drive Shaft - Take-Off Vibration at Low Speed
- Seat - Heating Element, Backrest And Cushion Replacement
- ABS Hydraulic Modulator - Revised
- Warranty - Allowance For Federal Tax On Freon
- Jack - New Type, Mounting
- A/C - Evaporator Condensate Drainage Modification
- Unleaded Fuel - Usage In Earlier Models
- M/T - Improved Reverse Shift Quality
- Seat Belt - Extensions
- Tools - Installation of Pinion Seal
- Air Bag System - System Life Expectancy
- Tires - Pressure Requirements/Recommendations
- Cam Gear P/S Racks - Bleeding
- A/C - Climate Control System Cleaning
- A/T - Coolant Contamination Information
- Engine - Pressure Washing Precautions
- A/T - Cooler/Line Flushing Information