Operation CHARM: Car repair manuals for everyone.
Home >> Ford >> 2000 >> Crown Victoria V8-4.6L VIN W >> Repair and Diagnosis >> Brakes and Traction Control >> Disc Brake System >> Brake Pad >> Service and Repair >> Rear
Manuals through 2025 now available!

Our trusted friends have launched a new website named LEMON, which has newer manuals. It also contains all the CHARM manuals.

LEMON is the spiritual successor to CHARM, I recommend you try it!

Link: lemon-manuals.la or lemon-manuals.org.ua

(Some people have issue connecting. LEMON is investigating. For now, use Firefox or change your DNS server)

Or, hide this message: temporarily or permanently

Rear

Removal





1. Inspect the brake pads for wear or contamination. Install new if worn to or past specification.

2. Note: It is not necessary to remove the rear wheel brake hose when performing this procedure.

Remove the rear disc brake caliper.





3. CAUTION: Do not allow grease, oil, brake fluid or other contaminants to contact the brake pads.

Remove the brake pads by pushing inward and rotating the pad up.





4. Note: Use a block of wood or used pad to protect the piston and boots.

Retract the caliper piston into the rear disc brake caliper.





5. Make sure the slippers are clean and in good condition.

Installation





1. CAUTION: Install the brake pads in full axle sets. Do not replace worn brake pads on only one side of vehicle.

Install the brake pads.
2. Install the rear disc brake caliper.
3. Verify correct brake operation.
pro multis · About Operation CHARM