Quarter Glass - Rattle/Squeak While Driving
00-044May 2, 2000
Applies To:
1996-00 Civic 2-door - - - ALL
Rattle or Squeak From the Quarter Glass
SYMPTOM
One or both quarter glass windows rattle or squeak while driving.
PROBABLE CAUSE
Paint primer on the quarter glass molding is rubbing on the window flange.
CORRECTIVE ACTION
Cut off the four rubber ribs of the affected rear quarter glass molding.
WARRANTY CLAIM INFORMATION
In warranty:
The normal warranty applies.
Out of warranty:
Any repair performed after warranty expiration may be eligible for goodwill consideration by the District Service Manager or your Zone Office. You must request consideration, and get a decision, before starting work.
REPAIR PROCEDURE
1. Locate the rubber ribs on the inside edge of the quarter glass molding.
2. Apply masking tape to the end of a trim removal tool.
3. At each rib location, slide the tip of the trim removal tool under the outer lip of the molding. Put a piece of cardboard between the tool and the glass to prevent scratching the glass, then pry the molding off the glass.
4. Twist the molding to expose each rib, then cut off the rib with a razor knife.
5. After cutting off all four ribs, twist the molding back into position, and reinstall it around the quarter glass. If needed, use silicone spray to lubricate the molding and make reinstallation easier.
6. test-drive the vehicle to make sure the rattle or squeak is gone.
Disclaimer