REAR WASHER HOSE REMOVAL/INSTALLATION

id091900801600

1.  Disconnect the negative battery cable. (See NEGATIVE BATTERY CABLE DISCONNECTION/CONNECTION [SKYACTIV-G 2.0, SKYACTIV-G 2.5].) (See NEGATIVE BATTERY CABLE DISCONNECTION/CONNECTION [SKYACTIV-G 2.0, SKYACTIV-G 2.5 (WITHOUT i-stop)].) (See NEGATIVE BATTERY CABLE DISCONNECTION/CONNECTION [SKYACTIV-D 2.2].)

2.  Remove the mudguard (RH). (See MUDGUARD REMOVAL/INSTALLATION.)

3.  Disconnect the rear washer hose A from the washer motor.

4.  Remove the rear washer hose A from the washer tank hook.

5.  Remove the rear washer hose A from clips A and B.

6.  Disconnect the rear washer hose A from the joint pipe A and remove it.

7.  Disconnect the rear washer hose B from the joint pipe A.

am6zzw00009077

8.  Remove the sunroof seaming welt. (with sunroof system)

9.  Remove the A pillar trim. (See A-PILLAR TRIM REMOVAL/INSTALLATION.)

10.  Disconnect the rear washer hose B from the joint pipe B and remove it.

11.  Disconnect the rear washer hose C from the joint pipe B.

ac5wzw00001625

12.  Remove the following parts:

(1)  Sunvisor (See SUNVISOR REMOVAL/INSTALLATION.)

(2)  Front map light (See MAP LIGHT REMOVAL/INSTALLATION.)

(3)  Assist handle (See ASSIST HANDLE REMOVAL/INSTALLATION.)

(4)  Front scuff plate (See FRONT SCUFF PLATE REMOVAL/INSTALLATION.)

(5)  Rear scuff plate (See REAR SCUFF PLATE REMOVAL/INSTALLATION.)

(6)  B-pillar lower trim (See B-PILLAR LOWER TRIM REMOVAL/INSTALLATION.)

(7)  Adjust anchor cover (See FRONT SEAT BELT REMOVAL/INSTALLATION.)

(8)  Upper anchor installation bolt on the seat belt (See FRONT SEAT BELT REMOVAL/INSTALLATION.)

(9)  B-pillar upper trim (See B-PILLAR UPPER TRIM REMOVAL/INSTALLATION.)

(10)  Rear seat cushion (See REAR SEAT CUSHION REMOVAL/INSTALLATION.)

(11)  Rear seat belt lower anchor installation bolt (See REAR SEAT BELT REMOVAL/INSTALLATION.)

(12)  Trunk board (See TRUNK BOARD REMOVAL/INSTALLATION.)

(13)  Trunk side pocket (See TRUNK SIDE POCKET REMOVAL/INSTALLATION.)

(14)  Trunk side upper trim (See TRUNK SIDE UPPER TRIM REMOVAL/INSTALLATION.)

(15)  C-pillar trim (See C-PILLAR TRIM REMOVAL/INSTALLATION.)

(16)  D-pillar trim (See D-PILLAR TRIM REMOVAL/INSTALLATION.)

(17)  Headliner (See HEADLINER REMOVAL/INSTALLATION.)

13.  Remove the tape and clips shown in the figure.

Without sunroof

am6zzw00009078

With sunroof

am6zzw00009079

14.  Disconnect the rear washer hose C from the joint pipe C and remove it.

15.  Disconnect the rear washer hose D from the joint pipe C.

ac5wzw00001628

16.  Remove the liftgate upper trim. (See LIFTGATE UPPER TRIM REMOVAL/INSTALLATION.)

17.  Partially peel the liftgate grommet in the direction of arrow (1) shown in the figure, and remove the liftgate grommet from the liftgate grommet inner.

ac5wzw00004636

18.  Using a tape-wrapped flathead screwdriver, press the liftgate grommet inner tabs A in the directions of arrows (2) and (3) shown in the figure and remove the liftgate grommet inner from the liftgate in the direction of arrow (4).

ac5jjw00001537

19.  Disconnect the rear washer hose D from the rear washer nozzle and remove it.

am6zzw00010782

20.  Install in the reverse order of removal.