REAR DRAIN HOSE INSTALLATION

id091500801600

Caution

•  If the rear drain hose is pinched or bent anywhere, the water in the hose may not discharge and enter the inside of the vehicle. During and after installation of the trims and the headliner, always make sure there is no interference with the rear drain hose. Fix any problem if found.

1.  Apply soapy water to the rear drain hose inserting area.

2.  Insert one end (the wider side) of the rear drain hose into the sunroof frame.

3.  Install the rear drain hose to the clips parallel to the pillar and free of slack.

4.  Insert the rear drain hose joint into the rear pillar inner hole.

5.  Connect the rain sensor connector. (vehicles with rain sensor)

6.  Connect the dimming mirror connector. (vehicles with dimming mirror)

7.  Install the following parts:

(1)  Headliner (See HEADLINER REMOVAL/INSTALLATION.)

(2)  Assist handle (See ASSIST HANDLE REMOVAL/INSTALLATION.)

(3)  Sunvisor (See SUNVISOR REMOVAL/INSTALLATION.)

(4)  Map light (See MAP LIGHT REMOVAL/INSTALLATION.)

(5)  C-pillar trim (See C-PILLAR TRIM REMOVAL/INSTALLATION.)

(6)  Trunk side upper trim (5HB) (See TRUNK SIDE UPPER TRIM REMOVAL/INSTALLATION.)

(7)  Tire house trim (See TIRE HOUSE TRIM REMOVAL/INSTALLATION.)

(8)  Rear seat cushion (See REAR SEAT CUSHION REMOVAL/INSTALLATION.)

(9)  B-pillar upper trim (See B-PILLAR UPPER TRIM REMOVAL/INSTALLATION.)

(10)  Upper anchor of the front seat belt (See FRONT SEAT BELT REMOVAL/INSTALLATION.)

(11)  B-pillar lower trim (See B-PILLAR LOWER TRIM REMOVAL/INSTALLATION.)

(12)  Rear scuff plate (See REAR SCUFF PLATE REMOVAL/INSTALLATION.)

(13)  Front scuff plate (See FRONT SCUFF PLATE REMOVAL/INSTALLATION.)

(14)  A-pillar trim (See A-PILLAR TRIM REMOVAL/INSTALLATION.)

(15)  Sunroof seaming welt

8.  Connect the rain sensor connector. (Vehicles with auto light / wiper system)

9.  Install the rain sensor cover. (Vehicles with auto light / wiper system) (See RAIN SENSOR REMOVAL/INSTALLATION.)

10.  Install the seaming welt.

11.  Connect the negative battery cable. (See BATTERY REMOVAL/INSTALLATION [MZR 1.5, MZR 1.6].)(See BATTERY REMOVAL/INSTALLATION [MZR 2.0, MZR 2.5].)(See BATTERY REMOVAL/INSTALLATION [MZR 2.0 DISI i-stop].)(See BATTERY REMOVAL/INSTALLATION [MZR 2.3 DISI Turbo].)(See BATTERY REMOVAL/INSTALLATION [MZR-CD 2.2].)(See BATTERY REMOVAL/INSTALLATION [SKYACTIV-G 2.0].)(See BATTERY REMOVAL/INSTALLATION [MZ-CD 1.6].)